The right sized sprayer for the job

In June (2014), I was invited to Durocher Farm in New Hampshire to see their new airblast sprayer. In years previous, spotted-wing drosophila was a significant pest in this two acre high bush blueberry planting. Since purchasing their new sprayer, they haven't had any trouble. That's quite an endorsement!

I'm not sure what I expected, but it wasn't this tiny Italian-made Carrarospray (Figure 1). Designed to be pulled behind vehicles without PTO, this 400 litre airblast featured adjustable air deflectors, and was powered by a Briggs & Stratton four-stroke engine. It even had a trash guard, a "kick-stand" and a clean water tank for hand washing.

Figure 1 - The Carrarospray ATVM (200 L pictured)

Figure 1 - The Carrarospray ATVM (200 L pictured)

The value of such a small sprayer in blueberries was immediately obvious. It fit beautifully between the bushes, so the potential for physical damage to the berries was nil. The pull-start motor burned very little fuel and compared to a full-size sprayer, made less noise. The sprayer was pulled (in this case) by a mower, so the grower not only sprayed, but mowed his alleys at the same time.

However, the best feature was the two-foot diameter fan and deflectors - here's why:

When I participate in sprayer workshops or help operators with coverage and calibration issues, it almost always comes down to matching the air to the crop canopy. In the case of grape, cane and bush crops, we struggle to choke back the air. Gear-up Throttle-down, fan gear and blade pitch are often brought into play. Exhausting those options, we've even had sprayer operators speed up to reduce the blow-through.

In this case, the air speed and volume was sufficient to displace the air in the blueberry canopy and replace it with spray-laden air with minimal blow-through. Combined with an appropriate spray volume and distribution over the boom, the results were excellent coverage and high efficiency (Figure 2).

Figure 2 - Coverage from the top-centre of the bush. Card is 2x3 inches.

Figure 2 - Coverage from the top-centre of the bush. Card is 2x3 inches.

Want to see the sprayer in action?

Want to hear from the grower himself?

Then go to www.sprayers101.ca to watch our short video.

Thanks to George Hamilton (UNH Cooperative Extension), Kitt Plummer (Durocher Farm), Kerry Hoffman-Richards (Penn State Pesticide Education Program) and Chazzbo Media for making this video possible.


For more information:
Toll Free: 1-877-424-1300
E-mail: ag.info.omafra@ontario.ca